Water Expert Andy Ball: Scaling and Fouling


Make text smaller Make text larger



Photos



  • Andy Ball



What is meant by scaling or fouling?


Fouling refers to the accumulation of unwanted material on solid surfaces, most often in an aquatic environment. The fouling material can consists of either living organisms (biofouling) or be a non-living substance (inorganic or organic). Other terms used in the literature to describe fouling include: deposit formation, encrustation, scaling, scale formation, crudding, and deposition. The last four terms are less inclusive than fouling; therefore, they should be used with caution. Components subject to fouling

The following lists examples of components that may be subject of fouling and the direct effects of fouling:

heat exchanger surfaces – reduces thermal efficiency, increases temperature, creates corrosion, increases use of cooling water piping, flow channels – reduces flow, increases pressure drop, increases energy expenditure, may create flow oscillations ship hulls – increases fuel usage, reduces maximum speed turbines – reduces efficiency, increases probability of failure solar panels – decreases the electrical power generated reverse osmosis membranes – reduces efficiency of water purification, increases pressure drop, increases energy expenditure electrical heating elements – increases temperature of the element, increases corrosion, reduces lifespan nuclear fuel in pressurized water reactors – axial offset anomaly injection/spray nozzles (e.g., a nozzle spraying a fuel into a furnace) – incorrect amount injected, malformed jet, component inefficiency, component failure venturi tubes, orifice plates – inaccurate or incorrect measurement of flow rate pitot tubes in airplanes – inaccurate or incorrect indication of airplane speed teeth – promotes tooth disease, decreases aesthetics

Andy Ball
862-354-7698




Make text smaller Make text larger

Comments

Pool Rules



MUST READ NEWS

Uncertainty shadows Pennsylvania's debate over nuclear power
By Marc Levy
Four decades after Three Mile Island became shorthand for America's worst commercial nuclear power accident, financial rescues of nuclear power plants are...

Read more »
Image

Pike County is getting new paper-trail voting equipment
— Pike County will replace its voting machines with voter-verifiable paper trail equipment by the 2020 presidential primary, the...
Read more »
Image

Pike's Peek
Here's a clue that inspires warm thoughts on a cold February night: where have you seen this neat array of firewood? If you think you know, fill out the form below.
Read more »
Image

Pike's Peek
Good work by last week's "Peekers."
Pike County Commissioner Matt Osterberg writes that the detail in last week's clue may be found at the "County Building on...

Read more »
Image

VIDEOS



Subscribe to our mailing list

* indicates required
Community Newspapers



MOST READ

Where in answers
Pike's Peek
  • Feb 21, 2019

MOST COMMENTED



Weather in Milford, PA