Water Expert Andy Ball: Scaling and Fouling


Make text smaller Make text larger



Photos



  • Andy Ball



What is meant by scaling or fouling?


Fouling refers to the accumulation of unwanted material on solid surfaces, most often in an aquatic environment. The fouling material can consists of either living organisms (biofouling) or be a non-living substance (inorganic or organic). Other terms used in the literature to describe fouling include: deposit formation, encrustation, scaling, scale formation, crudding, and deposition. The last four terms are less inclusive than fouling; therefore, they should be used with caution. Components subject to fouling

The following lists examples of components that may be subject of fouling and the direct effects of fouling:

heat exchanger surfaces – reduces thermal efficiency, increases temperature, creates corrosion, increases use of cooling water piping, flow channels – reduces flow, increases pressure drop, increases energy expenditure, may create flow oscillations ship hulls – increases fuel usage, reduces maximum speed turbines – reduces efficiency, increases probability of failure solar panels – decreases the electrical power generated reverse osmosis membranes – reduces efficiency of water purification, increases pressure drop, increases energy expenditure electrical heating elements – increases temperature of the element, increases corrosion, reduces lifespan nuclear fuel in pressurized water reactors – axial offset anomaly injection/spray nozzles (e.g., a nozzle spraying a fuel into a furnace) – incorrect amount injected, malformed jet, component inefficiency, component failure venturi tubes, orifice plates – inaccurate or incorrect measurement of flow rate pitot tubes in airplanes – inaccurate or incorrect indication of airplane speed teeth – promotes tooth disease, decreases aesthetics

Andy Ball
862-354-7698




Make text smaller Make text larger

Comments

Pool Rules



MUST READ NEWS

Best and worst Halloween candy for children’s teeth
Halloween is just around the corner. And although candy consumption is almost unavoidable this time of year, the Academy of General Dentistry wants parents and children to know...
Read more »
Image

Are we positive? Yes we are!
Delaware Valley Elementary School hung up a banner in the cafeteria, where students from second through fifth grade were asked to write positive messages so that everyone could...
Read more »
Image

Tension over tattoos: Parents concerned about health effects, future employment
Seventy-eight percent of parents in a national poll had a clear answer when asked how they would react if their own teen wanted a tattoo: absolutely not.
However, another 1 in...

Read more »
Image

American Legion installs officers
The David McKelvy Peterson American Legion Post 254 in Honesdale recently announced its new officers for 2018-19: Commander James Bruck, First Vice Commander Chester Gorski,...
Read more »
Image

VIDEOS



Subscribe to our mailing list

* indicates required
Community Newspapers



MOST READ

Local News
Are we positive? Yes we are!
  • Oct 14, 2018
Local News
American Legion installs officers
  • Oct 14, 2018

MOST COMMENTED



Weather in Milford, PA